PDA

View Full Version : New build thread as the old ones no longer valid



Ricky Gareth Rykala
6th January 2019, 10:08 PM
Hiya guys.
Not using the van hardly if it all due to having a company vehicle... think in 2018 the van went to vanwest which is around 120 mile round trip for me, download festival around 300 mile and dubs of anarchy which is around 120 mile and that was its lot.. so 540 mile in year... whilst this is good for the mileage and fuel. Not very good on the van..
To cut along story short itís mot time and went up to take the van and the brakes are corroded and also the inside is damp..
so think itís time to forget the old build thread and start a new one as Iím going to strip the vans rear out and start a fresh as the the damp has wrecked the head lining and also warped the floor..
So just gonna strip out and start a fresh.


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

S49
6th January 2019, 10:10 PM
Keep us posted Rick.

Ricky Gareth Rykala
6th January 2019, 10:17 PM
Went up the farm this morning to get cracking on the stripping out of the van..
hereís the list of whatís been done so far:

Stripped out all electrical switches, sockets, fuse box, hook up, solar controller and inverter.

Removed and broke up the u shaped seating and wrapped up the upholstery and stored away..

Started removing the floor but found where it was a mini bus it has a full structure made out of 2x1 Chanel that was bolted to the floor..

No pictures as yet as this is just the boring stuff but when its completely bare will start adding some


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
6th January 2019, 10:31 PM
Keep us posted Rick.

Will do mate itís a nightmare as it just donít get used enough.. even had the works van at Malvern when I seen you guys


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
6th January 2019, 10:35 PM
Just gonna add a few pics of the outside as this isnít really going to change much..https://uploads.tapatalk-cdn.com/20190106/d489c46bfc9c5318267be50ede6056bd.jpghttps://uploads.tapatalk-cdn.com/20190106/8ba18d21005037cf01a0869892aa5e80.jpghttps://uploads.tapatalk-cdn.com/20190106/af0e50f6b5e5b8e2fa5fbb6006935748.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

S49
6th January 2019, 10:35 PM
Its a juggling act for us 4 vehicles and 2 drivers. Swap between the T4 and polo for work. Then guess what? Molly came back in the house yesterday and said "Corrado's got a flat battery"

Ricky Gareth Rykala
6th January 2019, 10:51 PM
Its a juggling act for us 4 vehicles and 2 drivers. Swap between the T4 and polo for work. Then guess what? Molly came back in the house yesterday and said "Corrado's got a flat battery"

Yeah thatís a bugger.. canít really swap between mine as need the works van for work itís two extremes got a 18 plate works van thatís already done 36000 mile in the past 8 months and the T4s only done 500 in the past 12 lol


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
13th January 2019, 05:13 PM
Not that much to do really before show season https://uploads.tapatalk-cdn.com/20190113/b457e6eabb6b5cf1a544af8cda8ac321.jpghttps://uploads.tapatalk-cdn.com/20190113/922b7ac23865e9d867c683957f142e6e.jpghttps://uploads.tapatalk-cdn.com/20190113/a91f695bbc37f991fdd1e71d271ca111.jpg


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

S49
13th January 2019, 05:15 PM
Just a little list then.

Ricky Gareth Rykala
13th January 2019, 05:16 PM
Sure thereís more but will remember when Iím doing it


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

S49
13th January 2019, 05:17 PM
It never stops does it? All good fun mind.

Ricky Gareth Rykala
13th January 2019, 05:20 PM
Yeah I know mate forgot to put down mot but that will be done when itís completed. Have all the bits here and got 17 days to book off work before the new tax year and I get every forth week off.. so should be done before vanwest


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
13th January 2019, 05:51 PM
It never stops does it? All good fun mind.

Least itís no rot to deal with yet as itís a 04


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Hans
13th January 2019, 05:53 PM
Yeah thatís a bugger.. canít really swap between mine as need the works van for work itís two extremes got a 18 plate works van thatís already done 36000 mile in the past 8 months and the T4s only done 500 in the past 12 lol


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)Same mate, 18 reg work van RHD manuel and LHD automatic T4. Sometimes traffic lights switch to green and that idiot revs the shit out without a gear [emoji23] [emoji23] [emoji23]

Sent from my SM-G930F using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
13th January 2019, 06:21 PM
Anyone want a coach build one cheap on eBay but itís a rip off you want to see how many cars his friend has lol


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
13th January 2019, 06:21 PM
Anyone want a coach build one cheap on eBay but itís a rip off you want to see how many cars his friend has lol


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

https://uploads.tapatalk-cdn.com/20190113/3321553b9028c628bf0824c382c55afc.jpg



Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
13th January 2019, 06:22 PM
Heís even got this one listed twice with two different prices lol


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Jonnybigballs85
13th January 2019, 06:26 PM
Iím buying it [emoji1303]





Twice...


Sent from my iPhone using Just T4s

Ricky Gareth Rykala
13th January 2019, 06:41 PM
Iím buying it [emoji1303]





Twice...


Sent from my iPhone using Just T4s

Theyíve all been removed John he was on holidays and selling over a 100 cars for a mate who didnít have a eBay account. Everything from a Mexico rally car for 3500 to a mint mini pick up for 3400 to a 280 bhp 1.4 polo lmao


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Jonnybigballs85
13th January 2019, 07:18 PM
Almost as bad as this bloke...

http://just-t4s.co.uk/mobile-gallery/fe1ee160b80df7a8550bae51a416c259.jpg


Sent from my iPhone using Just T4s

Jonnybigballs85
13th January 2019, 07:19 PM
How does it hold on mate? Is it just clips?


Sent from my iPhone using Just T4s

Ricky Gareth Rykala
14th January 2019, 08:59 AM
How does it hold on mate? Is it just clips?


Sent from my iPhone using Just T4s

Yes mate just bolt the clips to the protector then it clips on to the bonnet


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

jo t4
14th January 2019, 01:26 PM
If you donít want it mate il have it ,if u can post Ricky or hold till vanwest [emoji51]


Sent from my iPhone using Just T4s

DonH
15th January 2019, 05:15 PM
Just a quick couple of questions, what size wheels and tyres are you running on and do you have a door wedge?

Ricky Gareth Rykala
15th January 2019, 07:10 PM
18s 225 40 18 no wedge


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
16th January 2019, 09:12 PM
If you donít want it mate il have it ,if u can post Ricky or hold till vanwest [emoji51]


Sent from my iPhone using Just T4s

Sorry jo adventure van had already messaged asking about it so he has first refusal


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

jo t4
16th January 2019, 11:27 PM
Sorry jo adventure van had already messaged asking about it so he has first refusal


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Yer thatís who I was referring to in my post , if he didnít end up wanting it - wouldnít q jump lol


Sent from my iPhone using Just T4s

Ricky Gareth Rykala
17th January 2019, 08:44 PM
https://uploads.tapatalk-cdn.com/20190117/88ead309351430cbc99c8315c40b4833.jpghttps://uploads.tapatalk-cdn.com/20190117/4e0821f26039323dc269e944125ff231.jpghttps://uploads.tapatalk-cdn.com/20190117/7ea1e35913ad12345647fe98818517be.jpghttps://uploads.tapatalk-cdn.com/20190117/156f564a0bb8be18312a7aa369ef9cba.jpghttps://uploads.tapatalk-cdn.com/20190117/c2e02423e41143515a6245af87a7b233.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
17th January 2019, 08:45 PM
Just thought Iíd add a few of the older pics off the other build thread as these mods are all being kept


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
23rd January 2019, 06:52 PM
Started on making the new cupboards today just got to t trim it now


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
23rd January 2019, 06:55 PM
https://uploads.tapatalk-cdn.com/20190123/1b749a9956ec9bf2a34552d855e145e5.jpghttps://uploads.tapatalk-cdn.com/20190123/8213c2a10e5c53361fe2b98e0eac17ef.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
23rd January 2019, 08:33 PM
Not sure if I should put a door or a curtain on the front curtains are so much easier as donít need the space for the door to open


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
7th February 2019, 03:57 PM
Ohh well been up the farm all day getting the subframe floor out that the seat rails was on. Was hoping I wouldnít need the welder but the floor is like a cheese grater not because of rust but the amount of holes they drilled in it.https://uploads.tapatalk-cdn.com/20190207/c8ca83b794539fc5f8747aad364c3b92.jpghttps://uploads.tapatalk-cdn.com/20190207/86b1a6c41de007183f45fb2987b2af3c.jpghttps://uploads.tapatalk-cdn.com/20190207/08e66477b07d6ba6e1c8c1146f8d76d8.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
7th February 2019, 03:58 PM
Ohh well been up the farm all day getting the subframe floor out that the seat rails was on. Was hoping I wouldnít need the welder but the floor is like a cheese grater not because of rust but the amount of holes they drilled in it.https://uploads.tapatalk-cdn.com/20190207/c8ca83b794539fc5f8747aad364c3b92.jpghttps://uploads.tapatalk-cdn.com/20190207/86b1a6c41de007183f45fb2987b2af3c.jpghttps://uploads.tapatalk-cdn.com/20190207/08e66477b07d6ba6e1c8c1146f8d76d8.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Itís the same on the other side and about another ten running up the centre


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

rjhoy02
7th February 2019, 04:40 PM
What did they do, sew them in? 🤣[emoji23]

Sent from the Midlands by pigeon

Ricky Gareth Rykala
7th February 2019, 05:29 PM
Seems like it mate


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

damien devil
7th February 2019, 06:04 PM
Looks like you've been having fun with the farms shot gun in their. .

Come rain or shine I'm out in mine!!

Sent from my Nokia 5.1 using Just T4s (http://r.tapatalk.com/byo?rid=87827)

arfur fox-acre
7th February 2019, 06:11 PM
What did they do, sew them in? ��[emoji23]

Sent from the Midlands by pigeon
hahahahhaaaa. nice

Ricky Gareth Rykala
11th March 2019, 04:25 PM
Not really done a lot on the van as been working a lot. However the floor is all welded up and have decided to take the van down the swamper route as itís kept up the farm and spends its life in the mud either up there or at shows..
hopefully the pictures will come on here fast this week as Iíve got the fortnight off..
Woke up this morning with a delivery from the meyle man[emoji1305]https://uploads.tapatalk-cdn.com/20190311/fa5b2b2133ae49267cc22244877aebf4.jpghttps://uploads.tapatalk-cdn.com/20190311/a2cd24cc8573346bf30e4f5b95b34855.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
11th March 2019, 04:29 PM
Hd shocks, hd ball joints, hd track rod ends, all new bottom and top arm bushes and new anti roll bar bushes and drop links..


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
11th March 2019, 04:32 PM
Also got six Passat 7.5 x16 steels from scrappy and also six part warn 215 70 16 bf Goodrich at tyreshttps://uploads.tapatalk-cdn.com/20190311/ccb6de1aaab80d38c0ec20d824e50834.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

damien devil
11th March 2019, 10:17 PM
Great keep us updated on progress with pics.

Come rain or shine I'm out in mine!!

Sent from my Nokia 5.1 using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
18th March 2019, 07:06 PM
A little bit of progress today
New radiator fitted and lifted the rear up on 1200kgs rear springs and 50 mm spacers.. havenít finished the back end yet as waiting for new brake callipers..https://uploads.tapatalk-cdn.com/20190318/4a4ea931ad6945f22b3f7a66d6854de1.jpghttps://uploads.tapatalk-cdn.com/20190318/b15107a0c4b3d2a9b0194f8cf00246a0.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
18th March 2019, 07:09 PM
Also stripped down the front passengers side ready for all the new goodieshttps://uploads.tapatalk-cdn.com/20190318/53060d52f386fe0d044a3b9211170e99.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
18th March 2019, 07:09 PM
More brown flecks than your nans hoop


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
18th March 2019, 07:12 PM
A little bit of progress today
New radiator fitted and lifted the rear up on 1200kgs rear springs and 50 mm spacers.. havenít finished the back end yet as waiting for new brake callipers..https://uploads.tapatalk-cdn.com/20190318/4a4ea931ad6945f22b3f7a66d6854de1.jpghttps://uploads.tapatalk-cdn.com/20190318/b15107a0c4b3d2a9b0194f8cf00246a0.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Itís now higher than a smack head on giro day


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Greeny gtc
18th March 2019, 10:35 PM
Where do you keep your Jack, in the sea?

Sent from my SM-G960F using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
18th March 2019, 10:36 PM
No mate out side the barn lol


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
18th March 2019, 10:36 PM
Itís about 20 years old


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Greeny gtc
18th March 2019, 10:37 PM
Itís about 20 years old


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)One of mine is and ain't that orange. [emoji12]

Sent from my SM-G960F using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
18th March 2019, 10:39 PM
Haha mate itís a rat jack


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Greeny gtc
18th March 2019, 10:40 PM
Haha mate itís a rat jack


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)Lol

Sent from my SM-G960F using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
19th March 2019, 05:12 PM
Not that much done today drove round all motor factors looking for some good quality cv boots but all of them only had crappy universal ones and TPS was 132 for the four so said no thanks to them..
Did however remove the bottom arm on passengers side and replace the bushes... replaced the anti roll bar bushes.. did have a new set of bushes for the top arm but they was fine so they go into the spares bin...



Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
19th March 2019, 05:13 PM
Also wire wheeled all the rust off and painted everything in black oxide ready to bolt back on


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
19th March 2019, 05:15 PM
Just ordered the boots from just campers as they were the cheapest any where especially as there the febi bilstein ones


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
20th March 2019, 02:00 PM
Boots arrived just got to get some motivation now to go fit them... really better quality than the factors ones and a really good price..


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
20th March 2019, 02:02 PM
https://uploads.tapatalk-cdn.com/20190320/aec3482b3e0c8b2bd391e9a0730f7b4f.jpghttps://uploads.tapatalk-cdn.com/20190320/19cd44a8be47d67bcd7ff5ba2d16758e.jpghttps://uploads.tapatalk-cdn.com/20190320/1024726e0b025514920bf84402fee687.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
21st March 2019, 06:40 PM
Bit more done today.. fitted the boots.. ball joints.. track rod ends.. wheel bearing.. damper.. bottom arm.. pads .. disks and also stainless brake lines to the passenger side front and also gave it all a lick of black oxide..https://uploads.tapatalk-cdn.com/20190321/c3beaacb511c0991ea63f5cc4b26096c.jpghttps://uploads.tapatalk-cdn.com/20190321/8fd7888f3925ab239b98ec3eef49f38c.jpghttps://uploads.tapatalk-cdn.com/20190321/59d09d88a11467406b7c6d95a2e8940d.jpghttps://uploads.tapatalk-cdn.com/20190321/3268ffba4524b718eaea529a3e18ba47.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
21st March 2019, 06:41 PM
Also my mate down the scrappy had a rhino rack come in that I managed to nab off him for 50 quid and a few beers https://uploads.tapatalk-cdn.com/20190321/3045b95757bc7f84b52b21bcfad19dc7.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

S49
21st March 2019, 07:56 PM
Hi Rick, what did you use to press the top ball joints out/in with mate?

Ricky Gareth Rykala
21st March 2019, 09:27 PM
Hi Rick, what did you use to press the top ball joints out/in with mate?

Hi mate I borrowed the tool for doing them


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

S49
22nd March 2019, 09:08 PM
I suspect i'll end up buying one.

Ricky Gareth Rykala
22nd March 2019, 10:20 PM
Yeah the one I borrowed was like 2 plates with threaded bars to clamp them together


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
22nd March 2019, 10:21 PM
Would be easy to make one up


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
22nd March 2019, 10:24 PM
I suspect i'll end up buying one.

Like this si https://uploads.tapatalk-cdn.com/20190322/0f2b3c148d46f8ba81dac617da1f68ff.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
22nd March 2019, 10:24 PM
Iím sure you have the skills to knock one up


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

S49
23rd March 2019, 05:23 AM
Will add that to my things to make list,, cheers Rick.

Ricky Gareth Rykala
23rd March 2019, 12:31 PM
Will add that to my things to make list,, cheers Rick.

I think there 50 to buy but if your like me I got most of the stuff here to knock one up


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
19th April 2019, 04:01 PM
Made a start on the back of the van yesterday and today..
New ply floor..
Lino
Bed frame
Step
https://uploads.tapatalk-cdn.com/20190419/f1001e20f8b18e6a6df4f892a115fdb0.jpghttps://uploads.tapatalk-cdn.com/20190419/b6c58ba29b159a40686a927d6db1e7c6.jpghttps://uploads.tapatalk-cdn.com/20190419/420d059d5e59ca218d554e4bfad3a62c.jpghttps://uploads.tapatalk-cdn.com/20190419/02ef23abefbe218a2f66c7db1718bbc0.jpghttps://uploads.tapatalk-cdn.com/20190419/22165b9bd5f98432de70e513364fb439.jpgIMG]https://uploads.tapatalk-cdn.com/20190419/4775fee6a805bece1a9b5af76962fd4d.jpg[/IMG]


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
19th April 2019, 04:02 PM
https://uploads.tapatalk-cdn.com/20190419/586f26e768b33de06740935c190a1021.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Jonnybigballs85
19th April 2019, 04:49 PM
Looking good ric [emoji1303]


Sent from my iPhone using Just T4s

Ricky Gareth Rykala
21st April 2019, 04:31 PM
Bit more progress todayhttps://uploads.tapatalk-cdn.com/20190421/ac063d2042e5021b1fe72f0069641878.jpghttps://uploads.tapatalk-cdn.com/20190421/73bc29849fe14ea1d9e24c1f0c1b6cd3.jpghttps://uploads.tapatalk-cdn.com/20190421/6cb424a0ef247f182629e7d6283bf3c4.jpghttps://uploads.tapatalk-cdn.com/20190421/c537a01dc017e85636a80d064d7fb789.jpghttps://uploads.tapatalk-cdn.com/20190421/b4603a35d61d1d7fa8f968b3f99c56ef.jpghttps://uploads.tapatalk-cdn.com/20190421/06a589cbfb3f31c52a977e5fbb2ad113.jpg



Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

arfur fox-acre
21st April 2019, 04:36 PM
Coming on nicely.
You have the same sub as me, with a little trimming they go under the driver's seat.

Ricky Gareth Rykala
21st April 2019, 05:46 PM
Coming on nicely.
You have the same sub as me, with a little trimming they go under the driver's seat.

Cheers arfur I have tried but couldnít get it under there what year is your van


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
27th April 2019, 04:04 PM
Bit more done today only tops left for cupboards and bed... installed table.. 240v .. switches.. sockets.. sink and hob..https://uploads.tapatalk-cdn.com/20190427/f27fabd71e8b65dc72a359a1c29c4e42.jpghttps://uploads.tapatalk-cdn.com/20190427/756194aba61a3e05583f545aeb5610bc.jpghttps://uploads.tapatalk-cdn.com/20190427/afb0a2a051ce7a68a6eba74ca9d0b54b.jpghttps://uploads.tapatalk-cdn.com/20190427/f30aac308cccb1522852b6e810ef09e2.jpghttps://uploads.tapatalk-cdn.com/20190427/f380547a9defd9bd35f642c649f80121.jpghttps://uploads.tapatalk-cdn.com/20190427/f949925a0c860486b46737fe1c6c8465.jpghttps://uploads.tapatalk-cdn.com/20190427/81e0dc6a2436bf72a092c271ebe09ca0.jpghttps://uploads.tapatalk-cdn.com/20190427/dcf9a84d0d56cc1593f4688b117214fc.jpghttps://uploads.tapatalk-cdn.com/20190427/567dab7258eb06c4d49a2d7af8629b56.jpghttps://uploads.tapatalk-cdn.com/20190427/4a1734119a840982854ed6e177eeeb1e.jpghttps://uploads.tapatalk-cdn.com/20190427/957d434fcc12df1641c2dc66485d1466.jpghttps://uploads.tapatalk-cdn.com/20190427/5d825c489ba7eeef712e1bf46ca9bd36.jpghttps://uploads.tapatalk-cdn.com/20190427/634b0c051cd5d92741305d96140b4d38.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

arfur fox-acre
28th April 2019, 11:11 AM
Cheers arfur I have tried but couldn’t get it under there what year is your van


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

98. Had to trim the seat base a little. Will post a pic later today

Ricky Gareth Rykala
28th April 2019, 04:51 PM
98. Had to trim the seat base a little. Will post a pic later today

Cheers arfur only asking as bases are narrower after 1997


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

arfur fox-acre
29th April 2019, 07:26 AM
Forgot to take the picture, will do it late tonight

Ricky Gareth Rykala
29th April 2019, 04:18 PM
Slow day today on the van fitted drls.. finished off all the electrics in the back and also got the cushions back in but need one more made for new layout..https://uploads.tapatalk-cdn.com/20190429/1964e9392d4b87e77c66f5b2a93c9a3e.jpghttps://uploads.tapatalk-cdn.com/20190429/d2dd22f197d5753e55a38831c9fdfd80.jpghttps://uploads.tapatalk-cdn.com/20190429/bf6a949f72980b97e723d95ea7262ab3.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

AndyLeach
29th April 2019, 04:54 PM
Slow day today on the van fitted drls.. finished off all the electrics in the back and also got the cushions back in but need one more made for new layout..https://uploads.tapatalk-cdn.com/20190429/1964e9392d4b87e77c66f5b2a93c9a3e.jpghttps://uploads.tapatalk-cdn.com/20190429/d2dd22f197d5753e55a38831c9fdfd80.jpghttps://uploads.tapatalk-cdn.com/20190429/bf6a949f72980b97e723d95ea7262ab3.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Love It 🤙🏽🤙🏽🤙🏽


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
30th April 2019, 07:17 PM
Bit more done today change drivers side bushes, brake lines, brakes, wheel bearing, damper, anti roll bar drop link and bush, disk and pads and cv boots, also Mam made the other cushion and swapped out the 50mm lift spacers to 25mm ones on the back and adjusted front to match.. only exhaust to swap and bleed the brakes mot and roof rack and van west here we come..https://uploads.tapatalk-cdn.com/20190430/4efe2f8ea58ce398fcddda1760a0788c.jpghttps://uploads.tapatalk-cdn.com/20190430/55209e89750d7bd8d21cef4e145c9308.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

arfur fox-acre
30th April 2019, 07:58 PM
Well done Sir

jo t4
30th April 2019, 08:53 PM
Looks lush mate


Sent from my iPhone using Just T4s

Ricky Gareth Rykala
30th April 2019, 09:36 PM
Cheers guys and girls


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Fruitbat
30th April 2019, 10:48 PM
What tv aerial have you got on the roof ? Is it any good , I’ve a nevcox and moonraker 1000 and I can’t get a signal on either and both have been tested .

Ricky Gareth Rykala
1st May 2019, 05:27 PM
Mine the same mate not sure on the make can only get itv


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

frenchdna
1st May 2019, 06:45 PM
Looks good.

Ricky Gareth Rykala
2nd May 2019, 09:54 PM
Mot day tomorrow hope it passes


Sent from my iPad using Just T4s (http://r.tapatalk.com/byo?rid=87827)

damont4
2nd May 2019, 10:09 PM
Good luck

Sent from my JSN-L21 using Tapatalk

Ricky Gareth Rykala
4th May 2019, 09:39 PM
Ohh well didnít even make it to the mot as was planning on plugging VCDS in that morning as lead broke and had new one but they wanted another 99 dollars out of me to register the new lead.. lucky enough hoopdub has come to the rescue and is lending me his for Monday [emoji3]


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
4th May 2019, 09:42 PM
Did however lower seat bases, fix door locks clean the back out and swapped over one of the new brake pipes back to the old one as they hadnít crimped it and it blew whilst pressure bleeding


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
4th May 2019, 09:51 PM
Ohh and fit passenger swivel and lowered passenger base an extra inch to drivers so are same hight


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

arfur fox-acre
5th May 2019, 11:45 AM
A bit late Ricky but here you go....another job for your list. Sorry.

12169

12170

A few pages back on my build thread has more pics of me fitting it. I have mine turned down to about a quarter so it still knocks out the bass under there.

Ricky Gareth Rykala
5th May 2019, 07:52 PM
Cheers arfur but Iíve mounted it now to the side of the cabinet behind the seat as I had to lower the bases aswell


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
7th May 2019, 05:17 PM
Fitted the exhaust and finally got on VCDS and sorted the rough idle out.. however when on VCDS it seems as though thereís no power getting to injector 5 as itís iq is stuck on 0 any ideas guys


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
7th May 2019, 05:19 PM
https://uploads.tapatalk-cdn.com/20190507/3c1ef3c01f73d92ecc3adc4581c52c54.jpg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Activ8
7th May 2019, 05:26 PM
Fitted the exhaust and finally got on VCDS and sorted the rough idle out.. however when on VCDS it seems as though thereís no power getting to injector 5 as itís iq is stuck on 0 any ideas guys


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)VCDS is displaying an adjustment IQ based on the needle sensor injector measurement. What we're the other 4 reading?

Ricky Gareth Rykala
7th May 2019, 05:29 PM
They was all within tolerance mate just worried about the 0


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
7th May 2019, 05:30 PM
At idle the overall qty was 3mg


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Activ8
7th May 2019, 05:46 PM
That's fine.

Ricky Gareth Rykala
7th May 2019, 05:50 PM
That's fine.

Awesome thanks active


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Activ8
7th May 2019, 05:58 PM
Just an after thought .... did you adjust the idle when oil, water & fuel cold or when it was up to temp?

Ricky Gareth Rykala
7th May 2019, 06:00 PM
It was up to temp mate


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
26th May 2019, 11:34 AM
Awesome news van sailed through itís mot with no advisoryís


Sent from my iPhone using Just T4s (http://r.tapatalk.com/byo?rid=87827)

Ricky Gareth Rykala
18th October 2019, 10:37 AM
Sorry guys I havenít added nothing to this thread in a while as been flat out with work. However had a awesome deal off the bay of e... Audi A6 rims fitted with Cooper ats that only had a months of use for 100



Sent from my iPad using Just T4s

Ricky Gareth Rykala
18th October 2019, 10:38 AM
https://uploads.tapatalk-cdn.com/20191018/250a9aa2a8519eae4cc87b7a96c6c222.jpg


Sent from my iPad using Just T4s

Ricky Gareth Rykala
18th October 2019, 10:39 AM
Also have a few more pics from the two shows.. bus fest and dubs of anarchy


Sent from my iPad using Just T4s

spedwing
18th October 2019, 10:40 AM
That is some big meat on the wheels 🤙


Sent from my iPhone using Just T4s

Ricky Gareth Rykala
18th October 2019, 10:59 AM
Also have a few more pics from the two shows.. bus fest and dubs of anarchy


Sent from my iPad using Just T4s

https://uploads.tapatalk-cdn.com/20191018/73ac58d303d87e1c5d9342898aef386f.jpghttps://uploads.tapatalk-cdn.com/20191018/7f3b10bd9ff983c8f1c0509a59edf0c9.jpghttps://uploads.tapatalk-cdn.com/20191018/2640c8286697a9cd52a875cf37b7ab06.jpg



Sent from my iPad using Just T4s

Ricky Gareth Rykala
18th October 2019, 11:01 AM
Also canít decide if to raptor the whole van or just the roof and the sills


Sent from my iPad using Just T4s